Oil & Natural Gas Projects
Exploration and Production Technologies
Altering Reservoir Wettability to Improve Production from Single Wells
The goal of the project is to develop a surfactant soak technique to improve
oil recovery by increasing the water-wettability of less than water-wet formations.
Encore Acquisition Company
Fort Worth, TX
University of Wyoming
Gel Technologies Corp.
Texland Petroleum, Inc.
Fort Worth, TX
Range Resources Corporation
Ft. Worth, TX
Yates Petroleum, Inc.
Technology developed for the Phosphoria formation in Wyoming is being adapted to the San Andres formation in the Permian Basin. Laboratory techniques developed during the course of an SBIR (Small Business Research Innovation) project that focused on the Phosphoria formation have also been extended to include the San Andres formation. Artificial intelligence (AI) correlations developed during the SBIR project were used to design surfactant soak treatments in the San Andres formation of the Fuhrman-Masho field near Andres, TX. AI techniques are being developed to establish baseline production trends in order to evaluate San Andres formation surfactant soak treatments in conjunction with the water-frac stimulation process.
Static imbibition tests with and without surfactant were completed with cores and fluids from the Cedar Creek anticline. The results indicate that a field test maybe warranted.
Low-cost surfactant soak stimulation treatments will prolong the life of marginally
economic wells in oil-wet reservoirs. About 22% of the original-oil-in-place
of the entire U.S. oil resource resides in shallow-shelf carbonate reservoirs.
Most of such reservoirs are oil-wet, heterogeneous, and naturally fractured,
and therefore ideal candidates for the surfactant soak process. An estimated
100,000 of the Nation's 500,000 domestic producing oil wells could benefit from
surfactant soak technology.
The project is the outgrowth of laboratory and fieldwork done to stimulate oil
production from the Phosphoria formation in Cottonwood Creek field. The low-volume
oil wells produce from a fractured, oil-wet carbonate reservoir in Wyoming.
Imbibition testing of reservoir cores and fluids in the laboratory suggested
the technique would work in the field.
The rate vs. cumulative chart suggests that the experimental treatments produced
about 25,000 bbl of incremental oil at a cost of $168,000. Of course, not all
treatments performed in an equal manner. The patterns observed in the gamma
ray log and the quantity of surfactant used with the incremental oil produced
were correlated using AI. Given the gamma ray log, the neural network correlation
of the standard deviation in the gamma ray log will be used to design surfactant
treatments for the San Andres formation.
The highlights of the project are as follows:
- Laboratory results indicate that the San Andres formation in the Permian Basin
is an excellent candidate for enhanced oil recovery via the surfactant soak
- Correlations developed in the Phosphoria formation are being used to design
surfactant soak treatments in the San Andres formation.
- Water-frac results in a tight San Andres oil reservoir were evaluated using
AI. The results will be used to analyze water-frac results plus surfactant in
the same field.
- Three San Andres surfactant soak treatments were approved operating company management.
Summary of surfactant soak treatment results in 22 of 23 wells tested.
Distribution of surfactant treatment results.
Current Status (July 2007)
Surfactant soaks field experiments have been completed in the Fuhrman-Masho (San Andres) pool in west Texas. Laboratory tests do not support a test of the surfactant soak process in the Eagle Creek field. All the proposed research work on this project has been successfully completed.
Project Start: October 1, 2004
Project End: September 30, 2006
Anticipated DOE Contribution: $799,747
Performer Contribution: $698,000 (47% of total)
NETL - Chandra Nautiyal (firstname.lastname@example.org or 918-699-2021)
Correlations - William Weiss (email@example.com or 505-838-3876)
Two papers were presented at a professional meeting and two peer-reviewed publications were accepted for publication in international journals.
Weiss, W.W., Xie, X., Weiss, J.W., Subramaniam, V., Taylor, A. and Edens, F., Artificial Intelligence Used to Evaluate 23 Single-Well Surfactant Soak Treatments, SPE 89457, presented at the 14th SPE/DOE Symposium on Improved Oil Recovery, Tulsa, OK, April 17-21, 2004.
Xie, X., Weiss, W.W., Tong, T., and Morrow, N.R., Improved Recovery from Carbonate Reservoirs by Chemical Stimulation, SPE 89424 presented at the 14th SPE/DOE Symposium on Improved Oil Recovery, Tulsa, OK, April 17-21, 2004.
Weiss, W.W., Weiss, J.W., Subramaniam, V., and Xie, X., AI Applied to Evaluate Waterflood Response, Gas Behind Pipe, and Imbibition Stimulation Treatments, Journal of Petroleum Science and Engineering, Vol. 49, Issues 3-4, December 15, 2005, Pages 110-121.
Weiss, W.W., Xie, X., Weiss, J.W., Subramanian, V., Taylor, A., and Edens, F., Artificial Intelligence Used to Evaluate 23 Single-Well Surfactant Soak Treatments, SPE Reservoir Evaluation & Engineering, June 2006 (in press).